ERTG Claims Service Banner
The Biogas Generator image

Biogas Generator Manufacturers

The Biogas Generator imageThe main biogas generator manufacturers are:

  • Jenbacher
  • Edina
  • Caterpiller.

For specific biogas generator suppliers go to our Biogas Electric Generator Suppliers List here.

How to Generate Electricity from a Biogas Digester

How is electricity produced using biogas produced by the anaerobic digestion process, is a common question asked. In fact there are now more than 150 searches per week on the phrase “electricity from methane digester”. So, in an effort to meet that demand on our web site I have written the article which follows.

It is possible to generate electricity from natural gas or biogas using a number of systems. In all cases the steps that must be gone through are twofold, chemical energy to mechanical energy, and then from mechanical energy to electrical energy.

For these conversion processes to be achieved, we need a suitable engine, and in principle there are two types of engine which have been used for biogas digester electricity generation, not including a hydrogen cell, and these are:

  • gas engine
  • turbine.

A gas engine is similar to a automobile car engine. It is an internal combustion engine which will burn the methane to convert the chemical bond energy of the gas to heat energy expanding the gases within the piston, driving the drive shaft and producing mechanical energy.

The mechanical energy in the rotating drive shaft is then coupled into an electrical generator.

The mechanical energy is utilized to drive the AC (alternating current) generator giving us electricity. Of course, the generator also has to be connected into an electrical power distribution grid, and to save on power loss during transmission through the cables the voltage is raised in a step-up transformer.

The cost of connection into the local power grid must always be considered when planning to build a biogas digester. At some locations this can be a very high cost, and this may have a big effect on the profitability of the digester until the capital cost is repaid.

A turbine converts methane into electricity through the same stages in a similar way. A jet engine is a form of turbine, and again the rotational energy is used to turn an electrical generator. Although turbines have been used they tend to be used only for very large power projects, and most biogas digesters are smaller than can economically justify a turbine.

It may seem a little strange to us to use gas in an engine, but the principle is actually very old and goes back to the first days of engine development. Early automotive engines used methane and coal gas. Petrol or gasoline usage was only developed later. Gottlieb Daimler and Carl Benz for example developed gas engines independently from one another in 1886, after they had been using gas engines. (The video below shows you this engine in action.)

When methane gas produced by a biogas digester is used for electricity production and the feedstock material is waste which would otherwise have been placed in a landfill a carbon dioxide emission credit reflecting the difference in greenhouse effect index between releasing landfill methane gas to the atmosphere and releasing the methane gas to the atmosphere as carbon dioxide, can be registered on emission credit markets in many countries.

Biogas digesters are already producing electrical power in many countries, and the number is growing. Starting recently, for example in the US, the methane created by decomposing garbage at the Winnebago Landfill was announced to be being piped to a new power plant at the site. There, four huge Caterpillar generators are using the methane to generate electricity, and it will be sent by power lines to users across a large region.

So, in order to prove the financial viability of a biogas digester project with electricity production we have to find out:

  • how much money we have to invest for these machines,
  • how efficiently we can generate,
  • and what would be price of producing our gas which will be burnt to generate a unit of electrical power.

A Combined Heat and Power (CHP) system is always worth considering. The idea of CHP is that it uses the hot water otherwise wasted when the excess heat is cooled before it can go back into the circuit.

Without the “cooling” provided by CHP, this heat goes into the atmosphere without serving any purpose. It is simply discharged in a cooling tower. CHP avoids this waste when it, for example, sends the hot water from the engine cooling system to warm other buildings etc.

CHP is a good way to gain better efficiency of power use, and usually too it should bring in further income to fund the biogas digester operation. Just as a radiator captures the excess heat from a car engine, a CHP system captures heat from the engine which can be pumped into radiators in nearby homes and factories for their use.

Install a Biogas Generator to save Fossil Fuel Use

The burning of biogas saves the burning of precious fossil fuel. Anaerobic digestion produces biogas and the burning of this gas provides a highly sustainable alternative to fossil fuel consumption.

Biogas generate as much electricity as possible to minimise global warming, and help to conserve the planet for future generations.

Important Benefit:

For Clean Development Mechanism (CDM) participating countries that can show that biogas is being created from the diversion of waste away from a methanogenic landfill, the carbon reduction (CER) payable is actually a valuable income. It has been as high as 20 to 21 times the methane tonnage.

As a result , those biogas generator projects using landfill diversion in their baseline assessments will have a head start in terms of viability when compared with non-methane related CDM projects.

Comments

    • Larry Ortiz
    • March 29, 2017
    Reply

    Hi there,I read your blog named “Biogas Generator Manufacturers” daily.Your humoristic style is witty, keep it up! And you can look our website about proxy list.

    • Yugal Sarkar
    • August 25, 2017
    Reply

    Wanted to say this blog is quite good. I always want to hear something totally new about cheap alternative energy because We have the same need for farm profits in my Country. So I read about the biogas subject, so this help´s me a lot. I did looking about the issue and located a large amount of blogs but nothing beats this. Thanks for sharing so much inside your blog..

  1. Reply

    I want to get across my joy in your generosity supporting biogas businesses that really want help on this issue of digesters. Your personal dedication to getting the solution around came to be quite effective. Your recommendations signifies a lot to me and my colleagues. Thanks a lot from a regular reader.

    • Snow Pool
    • April 17, 2018
    Reply

    “I am just starting to learn about all of this. I’m getting my ducks lined up to start my project. Without a good biogas generator it strikes me to be a rather pointless exercise to make the gas. Thanks for your help!”

    • Nali Brian
    • June 28, 2019
    Reply

    Excellent compilation! I wish to thank all readers who will ensure all biogas generators they buy are built to the highest standards and are applauded for their features like durability, reliability, optimum performance, efficiency, cost effectiveness and utility. When these are manufactured using premium quality materials and according to international quality standards it ensures the reputation of our trade.

  2. Reply

    The contents are masterly useful. Do you know MWM? These gas engines can be operated with various types of gas, such as natural gas, shale gas, mine gas, biogas, landfill gas, sewage gas, and syngas.

Leave a Reply

Your email address will not be published. Required fields are marked *

This site uses Akismet to reduce spam. Learn how your comment data is processed.

Advertisement Banner for Home Biogas Buddy.
0 Shares
Share
Tweet
Pin
Share